DEFORMATION DEPENDENCE OF POLYMER MATERIALS ON THE DOSE OF ELECTRONIC RADIATION
https://doi.org/10.52676/1729-7885-2018-4-104-106
Abstract
In this paper we consider the effect of high-energy electron irradiation, load and temperature on the mechanical properties of Mylar films. The simplest physical model is developed. Studies have shown that with an increase in the dose of electron irradiation to 104 Gy, there is a slow decrease in deformation for Mylar, and a further increase to 106 Gy leads to a sharp decrease in it. At the same time, with increasing temperature, the relative elongation increases by more than 50 %, associated with the growth of destructive processes in the material. The dependences of strain and stress on the dose of electron irradiation are described by exponential functions and are in satisfactory agreement with experimental data.
About the Authors
A. I. Kupchishin
Kazakh National Pedagogical University named after Abai;
Kazakh National University named after al-Farabi
Kazakhstan
Almaty
Kazakhstan
Almaty
B. G. Taipova
Kazakh National Pedagogical University named after Abai
Kazakhstan
Almaty
Kazakhstan
Almaty
N. A. Voronova
Kazakh National Pedagogical University named after Abai
Kazakhstan
Almaty
Kazakhstan
Almaty
A. M. Sushchikh
Kazakh National Pedagogical University named after Abai
Kazakhstan
Almaty
Kazakhstan
Almaty
References
1. Кудайкулова С.К., Искаков Р.М., Кравцова В.Д., Умерзакова М.Б., Abadie M., Жубанов Б.А. и др. Полимеры специального назначения. – Алматы, 2006. – 310 с.
2. Брукс Д., Джайлз Дж. Производство упаковки из ПЭТ/ пер. с англ. под ред. О. Ю. Сабсая. – СПб.: Профессия, 2006. – 368 с.
3. Ivchenko V.A. Atomic structure of cascades of atomic displacements in metals and alloys after different types of radiation// IOP Conf. Series: Materials Science and Engineering 110 012003. – 2016. – P. 1–5.
4. Tleukenov Y.O., Plotnikov S.V., Erdybaeva N.K., Pogrebnyak A.D. Studying of nanocomposite films’ structure and properties obtained by magnetron sputtering// IOP Conf. Series: Materials Science and Engineering 110 012004. – 2016. – P. 1–5.
5. Kupchishin A.I, Niyazov M.N., Voronova N.A., Kirdiashkin V.I., Abdukhairova A.T. The effect of temperature, static load and electron beam irradiation on the deformation of linear polymers// IOP Conf. Series: Materials Science and Engineering 168 012016 – 2017 – Р. 1–4.
6. Радиационная химия полимеров/ Под ред. В.А. Каргина. – М.: Наука, 1973. – 454 с.
7. Герасименко Н.Н., Воронова Н.А., Ковтунец В.А., Таипова Б.Г., Купчишин А.И., Омарбекова Ж.А. Исследование механических свойств полимерных пленок при воздействии на них статической нагрузки и температуры // Известия вузов. Материалы электронной техники. – 2003. – С. 6–12.
8. Уайт Дж.Л., Чой Д.Д. Полиэтилен, полипропилен и другие полиолефины. – Спб.: Профессия, 2006. – 368 с.
9. Kupchishin A.I., Taipova B.G., Kupchishin A.A., Voronova N.A., Kirdyashkin V.I., Fursa T.V. Catastrophic models of materials destruction// IOP Conf. Series: Material Science and Engineering. 110. 012037. – 2016. – Р. 1–5.
10. Лайус Л.А., Слуцкер А.И., Гофман И.В., Гиляров В.Л. Взаимосвязь характеристик обратимых термических и силовых деформаций в твердых телах различной структуры// Физика твердого тела. – 2004. – Т. 46, вып. 6. – С. 1115–1122.
11. Кудашев С.В., Урманцев У.Р., Селезнева Г.В., Рахимова Н.А., Желтобрюхов В.Ф. Поверхностная модификация гранул полиэтилентерефталата фторсодержащими уретанами// Журнал прикладной химии. – 2012. – Т. 85, вып. 11. – С. 1860–1866.
12. Fisher W., Korelli J. Effect of ionizing radiation of the chemical composition, crystalline content and structure and flow properties of PTFE// Ibid. – 1981. – Vol. 19, № 10. – P. 2465–2493.
Review
For citations:
Kupchishin A.I., Taipova B.G., Voronova N.A., Sushchikh A.M. DEFORMATION DEPENDENCE OF POLYMER MATERIALS ON THE DOSE OF ELECTRONIC RADIATION. NNC RK Bulletin. 2018;(4):104-106. (In Russ.) https://doi.org/10.52676/1729-7885-2018-4-104-106
Views:
255
Email this article 